Hi guys and gals

I have a problem with my rear window

Wound the window sown using the key and wound the window all the way to the bottom

Went to wind window back up and it would not budge

Window clicks but no movement... the motor always sounds fine and always worked ok.

tried using the button inside too.. to no avail

Any surf owners know what the problem might be??

I would think that it's one of the wires between the tailgate and main body of the surf, or failing that it's one of the relays in the control unit which is located behind the nearside trim.

You need to remove the tailgate panel and lubricate the motor and gears, once you have done that try reversing the power cables to the motor, if that works it has to be a broken cable of a fault in the relay box.

See here for more info http://www.showmesome.info/hilux/workshop/

cheers

I can hear the relay clicking when turning key

I can also hear a clicking near the motor

I tried winding the window up with tailgate down to see if the tailgate open buzzer works in wich is does.

Try looking at this write up, it tells you how to get the window up when the tailgate is open. http://www.showmesome.info/hilux/workshop/rear_door.htm

Make sure you support the glass when you do this.

hi andy

it doesnt tell you how to wind the window up?

but still a good article because the rear demister is not working.

I hope you have it fixed by now Steve but i did have this problem with mine at one point.

What i did was to open the tailgate clip in the catchs in the sides so it thinks the tailgate is in the closed position, remove the carpeted card, remove the access pannel by undoing the screws and then whilst turning the key in the to lift the window trying to help the window up to take the strain off the motor (just mind you fingers) which got the window up ( just remember to surport the window as it lifts)

I also cleaned the runners in the in the tailgate and the guides which the window runs up into when used normally and ive never had a problem since.

[quote=Andy,Aug 5 2005, 06:34 AM]
> I would think that it's one of the wires between the tailgate and
> main body of the surf, or failing that it's one of the relays in the
> control unit which is located behind the nearside trim.

Are the relays/fuses located behind the panel over the rear left wheel (94 Hilux Surf)? I hatwo problems with the tailgate: no power at the spade connectors on the demister at the window end, and no power to the window motor, so I am suspecting fuses/relays. I can get the window to go up & down by connecting a battery directly to the window motor connector.

The really annoying bit is that I have a manual, but the wiring only covers the pickup body. Looking at the wiring in the Hilux, with relays & fuses generally well marked, it looks like the rear window winder & heater were an afterthought :-)

Ciaran

The relays are behind the panel rear near side, but the most common thing is broken wires where it goes into the tailgate, you have checked the window lock button on the drivers arm rest, some people do forget about this.

I did not make that mistake (I was using the external keyswitch anyway, which is not affected by the window lock), but I made another equally stupid one. I had taken most of the tailgate apart and freed everything up (which with hindsight sorted it out) but I was getting no voltage at the motor terminals because the doorlock cables were not closing the limit switch. Dumb.

Thanks very much for the reply, it forced my brain to engage gear.

Ciaran

Hi guys and gals new to the forums and to my surf and have hit a strange one already my rear window works from the internal button but not from the key switch i can here a relay clicking when i turn the key but nothing from the window or motor any ideas where i should start looking

Thanks

Andi (The Doc)